Product ID:4286 HEAT RESISTANT TOPCOATS
MSDS Date:07/27/1988
FSC:8040
NIIN:00F026241
MSDS Number: BQHTM

RUST-OLEUM CORP

11 HAWTHORN PKWY
VERNON HILLS, IL 60061-1583
US

Emergency Phone: 708-367-7700 OR 708-864-8200

Info Phone: 708-367-7700

Cage: 08882

RUST-OLEUM CORP

VERNON HILLS, IL 60061-1583 US

Telephone: 847-367-7700

Cage: 08882

RESIN

PIGMENT

ADDITIVES

STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 35-40%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

TITANIUM DIOXIDE, TIO2

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 0-10%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

9.5-11.1

RTECS: 9999999WG

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: HARMFUL, NOSE & THROAT
IRRITATION. SKIN/EYES: IRRITATION. INGESTION: GASTROINTESTINAL
IRRITATION, NAUSEA, VOMITING, & DIARRHEA. ASPIRATION OF MATERIAL
INTO LUNGS CAN CAUSE CHEMICAL PNEUMON ITIS WHICH CAN BE FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: BRAIN & NERVOUS SYSTEM EFFECTS
CAUSING DIZZINESS, HEADACHE, NAUSEA. STAGGERING GAIT, CONFUSION,
UNCONSCIOUSNESS, OR COMA. PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
SKIN: DERMATITIS.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. EYES:
FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINS.
SKIN: WASH AFFECTED AREAS W/SOAP & WATER. INGESTION: DON'T INDUCE
VOMITING. K EEP PERSON WARM, QUIET. ASPIRATION HAZARD. OBTAIN
MEDICAL ATTENTION IN ALL CASES.

Flash Point Method:TCC
Flash Point:104F
Extinguishing Media:CO2, DRY CHEMICAL, OR FOAM
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT INCLUDING SCBA.
WATER SPRAY MAY BE INEFFECTIVE, BUT MAY BE USED TO COOL CLOSED
CONTAINERS. FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BUILD-UP PRESSURE,
AUTOIGNITE, OR EXPLODE IN EXTREME HEAT. COMBUSTIBLE PAINT LIQUID.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AREA
& REMOVE W/INERT ABSORBENT & NON-SPARKING TOOLS.

Handling and Storage Precautions:DON'T STORE >120F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED & PROTECTED FOR STORAGE OF NFPA
CLASS II COMBUSTIBLE LIQUIDS.
Other Precautions:CONTAINERS SHOULD BE GROUNDED WHEN POURING. EMPTY
CONTAINERS MAY BE HAZARDOUS. AVOID CONTACT W/SKIN. KEEP CONTAINERS
TIGHTLY CLOSED.

Respiratory Protection:USE NIOSH-APPROVED CHEMICAL CARTRIDGE RESPIRATOR
(TC23C) TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY & ORGANIC
VAPORS DURING SPRAY APPLICATION. IN CONFINED AREAS: USE NIOSH
APPROVED SUPPLIED-AIR R ESPIRATORS OR HOODS (TC19C).
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST: IN VOLUME OR PATTERN TO
KEEP TLV BELOW ACCEPTABLE LIMITS.
Protective Gloves:REQUIRED
Eye Protection:SPLASH-PROOF SAFETY GLASSES
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health

Boiling Pt:B.P. Text:307-389F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:57-66%

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXTREME HEAT, ELECTRICAL EQUIPMENT,
SPARKS, OPEN FLAMES, HOT SURFACES, TEMPS >120F, & OTHER SOURCES OF
IGNITION
Hazardous Decomposition Products:CO, CO2

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. DON'T INCINERATE CLOSED CONTAINERS.
COMBUSTIBLE PAINT LIQUID.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.